Ok I know this is a common problem with the earlier 8P's and I've read the threads on it being the temperature sender on the block, but my cars issue has a twist to it......
So the cooling fan on the radiator is spinning when the car is off (no key in ignition). It sounds like a jet plane and has drained the battery on my car. Basically the battery was dead yesterday morning I asked a mate to give me a jump start, it wouldn't start as the battery was completely drained. However we noticed that the fan was coming on at full pelt, and there was a clicking sound coming from the fuse box (under bonnet). Upon inspection- the relay (which I have since discovered is the fuel pump relay) was clicking away like one of the San Bushmen from South Africa lol
I took this relay out as I didn't like the constant clicking and the fan stopped spinning, result! Yeah right... Now car won't start, I now figure the relay does more than stop the fan spinning so out comes the battery to be charged as I didn't realize it was the fuel pump relay I'd pulled out just yet
4 hours later the battery has enough juice to start car up, but it won't start, light bulb goes off in my head and fuel pump relay gets fitted back into place, but car still doesn't start. Few mins and a fuel pressure warning sign later it turns over and starts up. I drive it for about 7 mins and the car conks out, on a roundabout (its a dsg may I add) so I embarrassingly push it off the roundabout and proceed to try and get the ****** thing started. Roughly another 7 mins goes past - by this point the fuel pump relay has been in and out loads of times, because although I know the car won't start without it in I still haven't figured out it's the fuel pump relay.... finally the car starts back up and I drive back home.
I sit in the car outside my home with it in 'N' position on the gearstick for a few mins to see if it conks out again and it does. Then I try restart it and it takes an age to start up runs for a few mins and conks out again. So I dig out the dodgy vag com lead I have and run a couple of scans it's getting cold so I call it a day and pull out the fuel pump relay (part no:1K0 906 381) to stop the fan from spinning and killling the battery again. Get upstairs and run the relay part number discovering that it controls the fuel pump too.
Any help here would be great, absolutely ****e timing considering I still have a few xmas pressie to buy lmao, and it's ****** freezing outside VCDS scan results are below, my lead isn't OG and didn't complete the first scan for some reason. 2nd one post clearing the fault codes ad restarting the car ran to the end though.
In case your wondering which relay I pulled it's the one marked light grey one marked 458 in this pic:
Edit: here are those vcds scans-
Scan1:
Chassis Type: 1K0
Scan: 01 02 03 08 09 15 16 17 19 25 37 42 44 46 47 52 56 77 7D
01-Engine -- Status: Malfunction 1010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
7D-Aux. Heat -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: None
Part No HW: 028 101 189 2
Revision: 12345678 Serial number: AUX7Z0D9FNT0NO
VCID: 55A58567BC1A496
3 Faults Found
16706 - Engine Speed Sensor (G28)
P0322 - 000 - No Signal
Freeze Frame:
RPM: 0 /min
Torque: 164.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 9.96 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
RPM: 84 /min
19781 - Power Supply Terminal 15
P3325 - 000 - Implausible - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 11.86 V
Bin. Bits: 00000111
Bin. Bits: 0
(no units): 1.0
19463 - Camshaft Position Sensor (G40)
P3007 - 000 - No Signal - Intermittent
Freeze Frame:
RPM: 84 /min
Torque: 34.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.01 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
(no units): 16.0
Readiness: N/A
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: None
Part No HW: 02E 927 770 AD
Revision: 00004010 Serial number: 00000410180173
VCID: 55A58567BC1A496
1 Fault Found
18258 - Powertrain Data Bus
P1850 - 000 - Missing Message from ECU - Intermittent
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No: 1K0 907 379 K
Component: ESP FRONT MK60 0104
Coding: 0023174
Shop #: WSC 06435 000 00000
VCID: 3A7F36DB754486E
2 Faults Found
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 8P0-820-043.lbl
Part No SW: 8P0 820 043 E HW: 8P0 820 043 E
Component: KlimavollautomatH13 0150
Revision: 034069 Serial number: 8P0820043
Shop #: WSC 06314 000 00000
VCID: 2E570A8BB90C5AE
2 Faults Found
01274 - Air Flow Flap Positioning Motor (V71)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 3
Fault Frequency: 4
Reset counter: 212
Mileage: 190026 km
Time Indication: 0
Freeze Frame:
Raw, Form. N/A: 000 000 135
Temperature: 14.0°C
(no units): 165.0
(no units): 37.0
Temperature: 10.5°C
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 2
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:11:20
Freeze Frame:
Voltage: 7.80 V
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 8P0-907-279-30-H.lbl
Part No SW: 8P0 907 279 K HW: 8P0 907 279 K
Component: Bordnetz-SG H54 2501
Revision: 00H54000 Serial number: 00000007998692
Coding: F3081E8290141C004F0000003000000000084E0364360802000000000000
Shop #: WSC 12435 123 12345
VCID: 458555270CBAF96
Subsystem 1 - Part No: 8P2 955 119 B
Component: Wischer AU350 H01 0130
Coding: 00062736
Shop #: WSC 12435
Subsystem 2 - Part No: 4E0 910 557
Component: REGENLICHTSENSORH10 0050
Coding: 00150573
Shop #: WSC 12435
4 Faults Found
00988 - Lamp for Brake Light; Right (M10)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 1
Fault Frequency: 3
Reset counter: 177
Mileage: 189176 km
Time Indication: 0
Date: 2013.10.25
Time: 20:48:00
Freeze Frame:
ON
Voltage: 11.90 V
ON
ON
OFF
OFF
ON
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:00
Freeze Frame:
OFF
Voltage: 7.05 V
OFF
OFF
OFF
OFF
OFF
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 4
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 11:41:00
Freeze Frame:
ON
Voltage: 9.10 V
ON
ON
OFF
OFF
ON
00318 - Supply Voltage for Rear Lid Control Module
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 4
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 11:41:00
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 8P0-959-655-94.lbl
Part No SW: 8P0 959 655 C HW: 8P0 959 655 C
Component: Airbag 9.41 H10 2620
Revision: 91H10262 Serial number: 00362000Z4FM
Coding: 0034622
Shop #: WSC 06314 000 00000
VCID: 428F4E3B1D94CEE
1 Fault Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 2
Reset counter: 21
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:12:14
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 8P0-953-549-F.lbl
Part No SW: 8P0 953 549 F HW: 8P0 953 549 F
Component: J0527 H36 0070
Coding: 0014112
Shop #: WSC 06314 000 00000
VCID: 418D41371892D56
Part No: XXXXXXXXXXX
Component: E0221 H06 0030
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 8P0-920-xxx-17-MY7.lbl
Part No SW: 8P0 920 981 A HW: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
Revision: D04 Serial number: 2249DD04002426
Coding: 0000443
Shop #: WSC 00022 210 98720
VCID: 366722EB415C62E
1 Fault Found
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 217
Mileage: 0 km
Time Indication: 0
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 D HW: 1K0 907 951
Component: Gateway H08 0100
Revision: 08 Serial number: 2500104A06018A
Coding: 3F3F0BCA072103
Shop #: WSC 00000 000 00000
VCID: 285BFC939BE804E
1 Fault Found
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 9
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 11:41:15
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: Redir Fail!
Part No SW: 8P0 920 981 A HW: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
Revision: D04 Serial number: AUX7Z0D9FNT0NO
Shop #: WSC 00000 000 00000
VCID: 366722EB415C62E
No fault code found.
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 8E0-035-192-RNSE.lbl
Part No SW: 8P0 035 192 H HW: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
Revision: 01S Serial number: AUZBZ7F0957072
Coding: 0205755
Shop #: WSC 06314 123 00000
VCID: 346318E3572070E
Part No: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
3 Faults Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
00879 - Connection to Speaker Front Right
011 - Open Circuit
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: None
Part No: 8P0
Component: Tuersteuerger. H10 0030
Coding: 0000048
Shop #: WSC 06314 000 00000
VCID: B87BACD3CB4814E
2 Faults Found
01811 - Supply Voltage for Door Controller; Drivers Side (J386)
002 - Lower Limit Exceeded - Intermittent
00913 - Window Regulator Switch; Front Right Driver (E81)
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: Redir Fail!
Part No: 1K2 909 144 H
Component: EPS_ZFLS Kl.8 1502
Shop #: WSC 00000 000 00000
VCID: 316D11F7A832456
3 Faults Found
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 6.0°C
Voltage: 7.20 V
Voltage: 8.10 V
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 4.0°C
Voltage: 8.60 V
Voltage: 10.00 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 8.0°C
Voltage: 6.10 V
Voltage: 6.00 V
-------------------------------------------------------------------------------
Address 46: Central Conv.
Cannot be reached
Scan 2 (after clearing codes and restarting car)
Chassis Type: 1K0
Scan: 01 02 03 08 09 15 16 17 19 25 37 42 44 46 47 52 56 62 72 77
7D
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 1010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: Malfunction 0010
72-Door, Rear Right -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
7D-Aux. Heat -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-016-BKD.lbl
Part No SW: 03G 906 016 DT HW: 028 101 189 2
Component: R4 2,0L EDC 0000AG 7000
Revision: 12345678 Serial number: AUX7Z0D9FNT0NO
Coding: 0000078
Shop #: WSC 66565 257 00032
VCID: 78FBECD30BC854E
3 Faults Found
16706 - Engine Speed Sensor (G28)
P0322 - 000 - No Signal
Freeze Frame:
RPM: 0 /min
Torque: 164.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 9.96 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
RPM: 84 /min
19781 - Power Supply Terminal 15
P3325 - 000 - Implausible - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 11.86 V
Bin. Bits: 00000111
Bin. Bits: 0
(no units): 1.0
19463 - Camshaft Position Sensor (G40)
P3007 - 000 - No Signal - Intermittent
Freeze Frame:
RPM: 84 /min
Torque: 34.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.01 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
(no units): 16.0
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-300-0xx.lbl
Part No SW: 02E 300 041 A HW: 02E 927 770 AD
Component: GSG DSG 041 0822
Revision: 00004010 Serial number: 00000410180173
Coding: 0000020
Shop #: WSC 06314 000 00000
VCID: 102BB47303786CE
1 Fault Found
18258 - Powertrain Data Bus
P1850 - 000 - Missing Message from ECU - Intermittent
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No: 1K0 907 379 K
Component: ESP FRONT MK60 0104
Coding: 0023174
Shop #: WSC 06435 000 00000
VCID: 3A7F36DB754486E
2 Faults Found
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 8P0-820-043.lbl
Part No SW: 8P0 820 043 E HW: 8P0 820 043 E
Component: KlimavollautomatH13 0150
Revision: 034069 Serial number: 8P0820043E
Shop #: WSC 06314 000 00000
VCID: 2E570A8BB90C5AE
2 Faults Found
01274 - Air Flow Flap Positioning Motor (V71)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 3
Fault Frequency: 4
Reset counter: 212
Mileage: 190026 km
Time Indication: 0
Date: 2013.12.10
Time: 18:47:19
Freeze Frame:
Voltage: 13.50 V
Temperature: 14.0°C
(no units): 165.0
(no units): 37.0
Temperature: 10.5°C
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 2
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:11:20
Freeze Frame:
Voltage: 7.80 V
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 8P0-907-279-30-H.lbl
Part No SW: 8P0 907 279 K HW: 8P0 907 279 K
Component: Bordnetz-SG H54 2501
Coding: Long Coding
VCID: 458555270CBAF96
Subsystem 1 - Part No: 8P2 955 119 B
Component: Wischer AU350 H01 0130
Coding: 00062736
Shop #: WSC 12435
Subsystem 2 - Part No: 4E0 910 557
Component: REGENLICHTSENSORH10 0050
Coding: 00150573
Shop #: WSC 12435
Part No: 8P0 907 279 K
Component: Bordnetz-SG H54 2501
Part No: 8P2 955 119 B
Component: Wischer AU350 H01 0130
Part No: 4E0 910 557
Component: REGENLICHTSENSORH10 0050
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 8P0-959-655-94.lbl
Part No SW: 8P0 959 655 C HW: 8P0 959 655 C
Component: Airbag 9.41 H10 2620
Revision: 91H10262 Serial number: 00
Shop #: WSC 06314 000 00000
VCID: 428F4E3B1D94CEE
1 Fault Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 2
Reset counter: 21
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:12:14
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 8P0-953-549-F.lbl
Part No SW: 8P0 953 549 F HW: 8P0 953 549 F
Component: J0527 H36 0070
Coding: 0014112
Shop #: WSC 06314 000 00000
VCID: 418D41371892D56
Part No: XXXXXXXXXXX
Component: E0221 H06 0030
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 8P0-920-xxx-17-MY7.lbl
Part No SW: 8P0 920 981 A HW: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
Coding: 0000443
Shop #: WSC 00022 210 98720
VCID: 366722EB415C62E
Part No: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 D HW: 1K0 907 951
Component: Gateway H08 0100
Serial number: 1K
Coding: 3F3F0BCA072103
Shop #: WSC 06314 000 00000
VCID: 285BFC939BE804E
Part No: 1K0 907 530 D
Component: Gateway H08 0100
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 25: Immobilizer
Cannot be reached
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 8E0-035-192-RNSE.lbl
Part No SW: 8P0 035 192 H HW: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
Revision: 01S Serial number: AUZBZ7F0957072
Coding: 0205755
Shop #: WSC 06314 123 00000
VCID: 346318E3572070E
Part No: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
3 Faults Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
Freeze Frame:
Voltage: 8.80 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
00879 - Connection to Speaker Front Right
011 - Open Circuit
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 8P0-959-801-MAX1.lbl
Part No: 8P0 959 801 F
Component: Tuersteuerger. H10 0030
Coding: 0000048
Shop #: WSC 06314 000 00000
VCID: 3E773ACB696CAAE
2 Faults Found
01811 - Supply Voltage for Door Controller; Drivers Side (J386)
002 - Lower Limit Exceeded - Intermittent
00913 - Window Regulator Switch; Front Right Driver (E81)
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: Redir Fail!
Part No: 1K2 909 144 H
Component: EPS_ZFLS Kl.8 1502
Shop #: WSC 00000 000 00000
VCID: 316D11F7A832456
3 Faults Found
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 6.0°C
Voltage: 7.20 V
Voltage: 8.10 V
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 4.0°C
Voltage: 8.60 V
Voltage: 10.00 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 8P0-959-433.lbl
Part No: 8P0 959 433 C
Component: KSG H04 0050
VCID: 3C7330C37F70B8E
Part No: 8P0 959 433 C
Component: KSG H04 0050
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 47: Sound System Labels: 8Px-035-382.lbl
Part No SW: 8P4 035 382 HW: 8P4 035 382
Component: AB2 SUBWOOFERBOXH03 0180
Shop #: WSC 00000 000 00000
VCID: F1ED51F7E8B2856
Part No: 8P4 035 382
Component: AB2 SUBWOOFERBOXH03 0180
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 8P0-959-802-MAX1.lbl
Part No: 8P0 959 802 F
Component: Tuersteuerger. H10 0030
Coding: 0000048
Shop #: WSC 06314 000 00000
VCID: 3F8947CF6E66A36
1 Fault Found
01812 - Supply Voltage for Door Controller; Pass. Side (J387)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 56: Radio Labels: 8E0-035-192-RNSE.lbl
Part No SW: 8P0 035 192 H HW: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
Revision: 01S Serial number: AUZBZ7F0957072
Coding: 0205755
Shop #: WSC 06314 123 00000
VCID: 346318E3572070E
3 Faults Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
Freeze Frame:
Voltage: 8.80 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 3
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.19
Time: 22:46:18
Freeze Frame:
Voltage: 10.50 V
Mileage: 190310 km
Count: 2012
Clock: 02:07
00879 - Connection to Speaker Front Right
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 14
Reset counter: 64
Mileage: 174187 km
Time Indication: 0
Date: 2012.06.29
Time: 20:16:58
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 8P4-959-801.lbl
Part No: 8P4 959 801 B
Component: Tuer-SG H10 0010
Coding: 0000144
Shop #: WSC 06314 000 00000
VCID: 3E773ACB696CAAE
1 Fault Found
01813 - Supply Voltage for Door Controller; Rear Left (J388)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 8P4-959-802.lbl
Part No: 8P4 959 802 B
Component: Tuer-SG H10 0010
Coding: 0000144
Shop #: WSC 06314 000 00000
VCID: 3F8947CF6E66A36
1 Fault Found
01814 - Supply Voltage for Door Controller; Rear Right (J389)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8P0 862 335 N HW: 8P0 862 335 N
Component: FSE_256x BT H34 0520
Revision: 00000000 Serial number: 00000005023259
Coding: 0011422
Shop #: WSC 63140 123 00000
VCID: 418D41371892D56
No fault code found.
-------------------------------------------------------------------------------
Address 7D: Aux. Heat Labels: 1K0-963-235.lbl
Part No SW: 1K0 963 235 E HW: 1K0 963 235 E
Component: PTC-Element
Revision: 00800000 Serial number:
Shop #: WSC 00000 000 00000
VCID: 2D550D87B40A216
No fault code found.
End ---------------------------------------------------------------------
So the cooling fan on the radiator is spinning when the car is off (no key in ignition). It sounds like a jet plane and has drained the battery on my car. Basically the battery was dead yesterday morning I asked a mate to give me a jump start, it wouldn't start as the battery was completely drained. However we noticed that the fan was coming on at full pelt, and there was a clicking sound coming from the fuse box (under bonnet). Upon inspection- the relay (which I have since discovered is the fuel pump relay) was clicking away like one of the San Bushmen from South Africa lol
I took this relay out as I didn't like the constant clicking and the fan stopped spinning, result! Yeah right... Now car won't start, I now figure the relay does more than stop the fan spinning so out comes the battery to be charged as I didn't realize it was the fuel pump relay I'd pulled out just yet4 hours later the battery has enough juice to start car up, but it won't start, light bulb goes off in my head and fuel pump relay gets fitted back into place, but car still doesn't start. Few mins and a fuel pressure warning sign later it turns over and starts up. I drive it for about 7 mins and the car conks out, on a roundabout (its a dsg may I add
) so I embarrassingly push it off the roundabout and proceed to try and get the ****** thing started. Roughly another 7 mins goes past - by this point the fuel pump relay has been in and out loads of times, because although I know the car won't start without it in I still haven't figured out it's the fuel pump relay.... finally the car starts back up and I drive back home. I sit in the car outside my home with it in 'N' position on the gearstick for a few mins to see if it conks out again and it does. Then I try restart it and it takes an age to start up runs for a few mins and conks out again. So I dig out the dodgy vag com lead I have and run a couple of scans it's getting cold so I call it a day and pull out the fuel pump relay (part no:1K0 906 381) to stop the fan from spinning and killling the battery again. Get upstairs and run the relay part number discovering that it controls the fuel pump too.
Any help here would be great, absolutely ****e timing considering I still have a few xmas pressie to buy lmao, and it's ****** freezing outside
VCDS scan results are below, my lead isn't OG and didn't complete the first scan for some reason. 2nd one post clearing the fault codes ad restarting the car ran to the end though.In case your wondering which relay I pulled it's the one marked light grey one marked 458 in this pic:
Edit: here are those vcds scans-
Scan1:
Chassis Type: 1K0
Scan: 01 02 03 08 09 15 16 17 19 25 37 42 44 46 47 52 56 77 7D
01-Engine -- Status: Malfunction 1010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
7D-Aux. Heat -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: None
Part No HW: 028 101 189 2
Revision: 12345678 Serial number: AUX7Z0D9FNT0NO
VCID: 55A58567BC1A496
3 Faults Found
16706 - Engine Speed Sensor (G28)
P0322 - 000 - No Signal
Freeze Frame:
RPM: 0 /min
Torque: 164.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 9.96 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
RPM: 84 /min
19781 - Power Supply Terminal 15
P3325 - 000 - Implausible - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 11.86 V
Bin. Bits: 00000111
Bin. Bits: 0
(no units): 1.0
19463 - Camshaft Position Sensor (G40)
P3007 - 000 - No Signal - Intermittent
Freeze Frame:
RPM: 84 /min
Torque: 34.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.01 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
(no units): 16.0
Readiness: N/A
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: None
Part No HW: 02E 927 770 AD
Revision: 00004010 Serial number: 00000410180173
VCID: 55A58567BC1A496
1 Fault Found
18258 - Powertrain Data Bus
P1850 - 000 - Missing Message from ECU - Intermittent
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No: 1K0 907 379 K
Component: ESP FRONT MK60 0104
Coding: 0023174
Shop #: WSC 06435 000 00000
VCID: 3A7F36DB754486E
2 Faults Found
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 8P0-820-043.lbl
Part No SW: 8P0 820 043 E HW: 8P0 820 043 E
Component: KlimavollautomatH13 0150
Revision: 034069 Serial number: 8P0820043
Shop #: WSC 06314 000 00000
VCID: 2E570A8BB90C5AE
2 Faults Found
01274 - Air Flow Flap Positioning Motor (V71)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 3
Fault Frequency: 4
Reset counter: 212
Mileage: 190026 km
Time Indication: 0
Freeze Frame:
Raw, Form. N/A: 000 000 135
Temperature: 14.0°C
(no units): 165.0
(no units): 37.0
Temperature: 10.5°C
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 2
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:11:20
Freeze Frame:
Voltage: 7.80 V
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 8P0-907-279-30-H.lbl
Part No SW: 8P0 907 279 K HW: 8P0 907 279 K
Component: Bordnetz-SG H54 2501
Revision: 00H54000 Serial number: 00000007998692
Coding: F3081E8290141C004F0000003000000000084E0364360802000000000000
Shop #: WSC 12435 123 12345
VCID: 458555270CBAF96
Subsystem 1 - Part No: 8P2 955 119 B
Component: Wischer AU350 H01 0130
Coding: 00062736
Shop #: WSC 12435
Subsystem 2 - Part No: 4E0 910 557
Component: REGENLICHTSENSORH10 0050
Coding: 00150573
Shop #: WSC 12435
4 Faults Found
00988 - Lamp for Brake Light; Right (M10)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 1
Fault Frequency: 3
Reset counter: 177
Mileage: 189176 km
Time Indication: 0
Date: 2013.10.25
Time: 20:48:00
Freeze Frame:
ON
Voltage: 11.90 V
ON
ON
OFF
OFF
ON
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:00
Freeze Frame:
OFF
Voltage: 7.05 V
OFF
OFF
OFF
OFF
OFF
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 4
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 11:41:00
Freeze Frame:
ON
Voltage: 9.10 V
ON
ON
OFF
OFF
ON
00318 - Supply Voltage for Rear Lid Control Module
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 4
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 11:41:00
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 8P0-959-655-94.lbl
Part No SW: 8P0 959 655 C HW: 8P0 959 655 C
Component: Airbag 9.41 H10 2620
Revision: 91H10262 Serial number: 00362000Z4FM
Coding: 0034622
Shop #: WSC 06314 000 00000
VCID: 428F4E3B1D94CEE
1 Fault Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 2
Reset counter: 21
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:12:14
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 8P0-953-549-F.lbl
Part No SW: 8P0 953 549 F HW: 8P0 953 549 F
Component: J0527 H36 0070
Coding: 0014112
Shop #: WSC 06314 000 00000
VCID: 418D41371892D56
Part No: XXXXXXXXXXX
Component: E0221 H06 0030
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 8P0-920-xxx-17-MY7.lbl
Part No SW: 8P0 920 981 A HW: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
Revision: D04 Serial number: 2249DD04002426
Coding: 0000443
Shop #: WSC 00022 210 98720
VCID: 366722EB415C62E
1 Fault Found
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 217
Mileage: 0 km
Time Indication: 0
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 D HW: 1K0 907 951
Component: Gateway H08 0100
Revision: 08 Serial number: 2500104A06018A
Coding: 3F3F0BCA072103
Shop #: WSC 00000 000 00000
VCID: 285BFC939BE804E
1 Fault Found
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 9
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 11:41:15
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: Redir Fail!
Part No SW: 8P0 920 981 A HW: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
Revision: D04 Serial number: AUX7Z0D9FNT0NO
Shop #: WSC 00000 000 00000
VCID: 366722EB415C62E
No fault code found.
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 8E0-035-192-RNSE.lbl
Part No SW: 8P0 035 192 H HW: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
Revision: 01S Serial number: AUZBZ7F0957072
Coding: 0205755
Shop #: WSC 06314 123 00000
VCID: 346318E3572070E
Part No: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
3 Faults Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
00879 - Connection to Speaker Front Right
011 - Open Circuit
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: None
Part No: 8P0
Component: Tuersteuerger. H10 0030
Coding: 0000048
Shop #: WSC 06314 000 00000
VCID: B87BACD3CB4814E
2 Faults Found
01811 - Supply Voltage for Door Controller; Drivers Side (J386)
002 - Lower Limit Exceeded - Intermittent
00913 - Window Regulator Switch; Front Right Driver (E81)
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: Redir Fail!
Part No: 1K2 909 144 H
Component: EPS_ZFLS Kl.8 1502
Shop #: WSC 00000 000 00000
VCID: 316D11F7A832456
3 Faults Found
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 6.0°C
Voltage: 7.20 V
Voltage: 8.10 V
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 4.0°C
Voltage: 8.60 V
Voltage: 10.00 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 8.0°C
Voltage: 6.10 V
Voltage: 6.00 V
-------------------------------------------------------------------------------
Address 46: Central Conv.
Cannot be reached
Scan 2 (after clearing codes and restarting car)
Chassis Type: 1K0
Scan: 01 02 03 08 09 15 16 17 19 25 37 42 44 46 47 52 56 62 72 77
7D
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 1010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: Malfunction 0010
72-Door, Rear Right -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
7D-Aux. Heat -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-016-BKD.lbl
Part No SW: 03G 906 016 DT HW: 028 101 189 2
Component: R4 2,0L EDC 0000AG 7000
Revision: 12345678 Serial number: AUX7Z0D9FNT0NO
Coding: 0000078
Shop #: WSC 66565 257 00032
VCID: 78FBECD30BC854E
3 Faults Found
16706 - Engine Speed Sensor (G28)
P0322 - 000 - No Signal
Freeze Frame:
RPM: 0 /min
Torque: 164.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 9.96 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
RPM: 84 /min
19781 - Power Supply Terminal 15
P3325 - 000 - Implausible - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 11.86 V
Bin. Bits: 00000111
Bin. Bits: 0
(no units): 1.0
19463 - Camshaft Position Sensor (G40)
P3007 - 000 - No Signal - Intermittent
Freeze Frame:
RPM: 84 /min
Torque: 34.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.01 V
Bin. Bits: 00000111
Idle Stabilization: 0.0°KW
(no units): 16.0
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-300-0xx.lbl
Part No SW: 02E 300 041 A HW: 02E 927 770 AD
Component: GSG DSG 041 0822
Revision: 00004010 Serial number: 00000410180173
Coding: 0000020
Shop #: WSC 06314 000 00000
VCID: 102BB47303786CE
1 Fault Found
18258 - Powertrain Data Bus
P1850 - 000 - Missing Message from ECU - Intermittent
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No: 1K0 907 379 K
Component: ESP FRONT MK60 0104
Coding: 0023174
Shop #: WSC 06435 000 00000
VCID: 3A7F36DB754486E
2 Faults Found
01314 - Engine Control Module
013 - Check DTC Memory - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 8P0-820-043.lbl
Part No SW: 8P0 820 043 E HW: 8P0 820 043 E
Component: KlimavollautomatH13 0150
Revision: 034069 Serial number: 8P0820043E
Shop #: WSC 06314 000 00000
VCID: 2E570A8BB90C5AE
2 Faults Found
01274 - Air Flow Flap Positioning Motor (V71)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 3
Fault Frequency: 4
Reset counter: 212
Mileage: 190026 km
Time Indication: 0
Date: 2013.12.10
Time: 18:47:19
Freeze Frame:
Voltage: 13.50 V
Temperature: 14.0°C
(no units): 165.0
(no units): 37.0
Temperature: 10.5°C
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 2
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:11:20
Freeze Frame:
Voltage: 7.80 V
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 8P0-907-279-30-H.lbl
Part No SW: 8P0 907 279 K HW: 8P0 907 279 K
Component: Bordnetz-SG H54 2501
Coding: Long Coding
VCID: 458555270CBAF96
Subsystem 1 - Part No: 8P2 955 119 B
Component: Wischer AU350 H01 0130
Coding: 00062736
Shop #: WSC 12435
Subsystem 2 - Part No: 4E0 910 557
Component: REGENLICHTSENSORH10 0050
Coding: 00150573
Shop #: WSC 12435
Part No: 8P0 907 279 K
Component: Bordnetz-SG H54 2501
Part No: 8P2 955 119 B
Component: Wischer AU350 H01 0130
Part No: 4E0 910 557
Component: REGENLICHTSENSORH10 0050
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 8P0-959-655-94.lbl
Part No SW: 8P0 959 655 C HW: 8P0 959 655 C
Component: Airbag 9.41 H10 2620
Revision: 91H10262 Serial number: 00
Shop #: WSC 06314 000 00000
VCID: 428F4E3B1D94CEE
1 Fault Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 2
Reset counter: 21
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:12:14
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 8P0-953-549-F.lbl
Part No SW: 8P0 953 549 F HW: 8P0 953 549 F
Component: J0527 H36 0070
Coding: 0014112
Shop #: WSC 06314 000 00000
VCID: 418D41371892D56
Part No: XXXXXXXXXXX
Component: E0221 H06 0030
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 8P0-920-xxx-17-MY7.lbl
Part No SW: 8P0 920 981 A HW: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
Coding: 0000443
Shop #: WSC 00022 210 98720
VCID: 366722EB415C62E
Part No: 8P0 920 981 A
Component: KOMBIINSTR. VDO H73 0300
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 D HW: 1K0 907 951
Component: Gateway H08 0100
Serial number: 1K
Coding: 3F3F0BCA072103
Shop #: WSC 06314 000 00000
VCID: 285BFC939BE804E
Part No: 1K0 907 530 D
Component: Gateway H08 0100
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 25: Immobilizer
Cannot be reached
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 8E0-035-192-RNSE.lbl
Part No SW: 8P0 035 192 H HW: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
Revision: 01S Serial number: AUZBZ7F0957072
Coding: 0205755
Shop #: WSC 06314 123 00000
VCID: 346318E3572070E
Part No: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
3 Faults Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
Freeze Frame:
Voltage: 8.80 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
00879 - Connection to Speaker Front Right
011 - Open Circuit
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 8P0-959-801-MAX1.lbl
Part No: 8P0 959 801 F
Component: Tuersteuerger. H10 0030
Coding: 0000048
Shop #: WSC 06314 000 00000
VCID: 3E773ACB696CAAE
2 Faults Found
01811 - Supply Voltage for Door Controller; Drivers Side (J386)
002 - Lower Limit Exceeded - Intermittent
00913 - Window Regulator Switch; Front Right Driver (E81)
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: Redir Fail!
Part No: 1K2 909 144 H
Component: EPS_ZFLS Kl.8 1502
Shop #: WSC 00000 000 00000
VCID: 316D11F7A832456
3 Faults Found
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 6.0°C
Voltage: 7.20 V
Voltage: 8.10 V
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Mileage: 280 km
Temperature: 4.0°C
Voltage: 8.60 V
Voltage: 10.00 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 8P0-959-433.lbl
Part No: 8P0 959 433 C
Component: KSG H04 0050
VCID: 3C7330C37F70B8E
Part No: 8P0 959 433 C
Component: KSG H04 0050
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 47: Sound System Labels: 8Px-035-382.lbl
Part No SW: 8P4 035 382 HW: 8P4 035 382
Component: AB2 SUBWOOFERBOXH03 0180
Shop #: WSC 00000 000 00000
VCID: F1ED51F7E8B2856
Part No: 8P4 035 382
Component: AB2 SUBWOOFERBOXH03 0180
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 8P0-959-802-MAX1.lbl
Part No: 8P0 959 802 F
Component: Tuersteuerger. H10 0030
Coding: 0000048
Shop #: WSC 06314 000 00000
VCID: 3F8947CF6E66A36
1 Fault Found
01812 - Supply Voltage for Door Controller; Pass. Side (J387)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 56: Radio Labels: 8E0-035-192-RNSE.lbl
Part No SW: 8P0 035 192 H HW: 8P0 035 192 H
Component: RNS-E HIGH EU H72 0660
Revision: 01S Serial number: AUZBZ7F0957072
Coding: 0205755
Shop #: WSC 06314 123 00000
VCID: 346318E3572070E
3 Faults Found
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.20
Time: 00:14:42
Freeze Frame:
Voltage: 8.80 V
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 3
Reset counter: 217
Mileage: 190311 km
Time Indication: 0
Date: 2013.12.19
Time: 22:46:18
Freeze Frame:
Voltage: 10.50 V
Mileage: 190310 km
Count: 2012
Clock: 02:07
00879 - Connection to Speaker Front Right
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 14
Reset counter: 64
Mileage: 174187 km
Time Indication: 0
Date: 2012.06.29
Time: 20:16:58
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 8P4-959-801.lbl
Part No: 8P4 959 801 B
Component: Tuer-SG H10 0010
Coding: 0000144
Shop #: WSC 06314 000 00000
VCID: 3E773ACB696CAAE
1 Fault Found
01813 - Supply Voltage for Door Controller; Rear Left (J388)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 8P4-959-802.lbl
Part No: 8P4 959 802 B
Component: Tuer-SG H10 0010
Coding: 0000144
Shop #: WSC 06314 000 00000
VCID: 3F8947CF6E66A36
1 Fault Found
01814 - Supply Voltage for Door Controller; Rear Right (J389)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8P0 862 335 N HW: 8P0 862 335 N
Component: FSE_256x BT H34 0520
Revision: 00000000 Serial number: 00000005023259
Coding: 0011422
Shop #: WSC 63140 123 00000
VCID: 418D41371892D56
No fault code found.
-------------------------------------------------------------------------------
Address 7D: Aux. Heat Labels: 1K0-963-235.lbl
Part No SW: 1K0 963 235 E HW: 1K0 963 235 E
Component: PTC-Element
Revision: 00800000 Serial number:
Shop #: WSC 00000 000 00000
VCID: 2D550D87B40A216
No fault code found.
End ---------------------------------------------------------------------
Last edited:
